Weber 300 Gas Grill User Manual


  Open as PDF
of 72
 
26
GAS INSTRUcTIoNS
1
2
REFILLING THE LIQUID PROPANE CYLINDER
We recommend that you refill the LP cylinder before it is completely empty.
Removal Of The LP Cylinder
A) Close cylinder valve (turn clockwise) (1).
B) Unscrew Regulator by turning counterclockwise, by hand only (2).
C) Remove LP Cylinder from tank bracket by rotating cylinder.
D) Lift cylinder off.
To refill, take LP cylinder to a “Gas Propane” dealer.
m WARNING: We recommend that your LP cylinder be filled
at an authorized LP gas dealer, by a qualified attendant,
who fills the cylinder by weight. IMPROPER FILLING IS
DANGEROUS.
m CAUTION: Place dust cap on cylinder valve outlet whenever
the cylinder is not in use. Only install the type of dust cap
on the cylinder valve outlet that is provided with the cylinder
valve. Other types of caps or plugs may result in leakage of
propane.
◆
SAFE HANDLING TIPS FOR LIQUID PROPANE GAS CYLINDERS
• LiquidPropane(LP)gasisapetroleumproductasaregasolineandnaturalgas.LP
gas is a gas at regular temperatures and pressures. Under moderate pressure, inside
a cylinder, LP gas is a liquid. As the pressure is released, the liquid readily vaporizes
and becomes gas.
• LPgashasanodorsimilartonaturalgas.Youshouldbeawareofthisodor.
• LPgasisheavierthanair.LeakingLPgasmaycollectinlowareasandprevent
dispersion.
• Tofill,taketheLPcylindertoagaspropanedealer,orlookup“gas-propane”inthe
phone book for other sources of LP gas.
m WARNING: We recommend that your LP cylinder be filled
at an authorized LP gas dealer, by a qualified attendant,
who fills the tank by weight. IMPROPER FILLING IS
DANGEROUS.
• AirmustberemovedfromanewLPcylinderbeforetheinitialfilling.YourLPdealeris
equipped to do this.
• TheLPcylindermustbeinstalled,transportedandstoredinanuprightposition.LP
cylinders should not be dropped or handled roughly.
• NeverstoreortransporttheLPcylinderwheretemperaturescanreach125°F(toohot
to hold by hand - for example: do not leave the LP cylinder in a car on a hot day).
Note: A refill will last about 18-20 hours of cooking time at normal use. You do not have
to run out before you refill.
• Treat“empty”LPcylinderswiththesamecareaswhenfull.EvenwhentheLPtank
is empty of liquid there still may be gas pressure in the cylinder. Always close the
cylinder valve before disconnecting.
m CAUTION: Place dust cap on cylinder valve outlet whenever
the cylinder is not in use. Only install the type of dust cap
on the cylinder valve outlet that is provided with the cylinder
valve. Other types of caps or plugs may result in leakage of
propane.
• DonotuseadamagedLPcylinder.DentedorrustyLPcylindersorLPcylinders
with a damaged valve may be hazardous and should be replaced with a new one
immediately.
Liquid Propane (LP) Cylinder(s)
• ThejointwherethehoseconnectstotheLPcylindermustbeleaktestedeachtime
the LP cylinder is reconnected. For example, test each time the LP cylinder is refilled.
• Besuretheregulatorismountedwiththesmallventholepointeddownwardsothatit
will not collect water. This vent should be free of dirt, grease, bugs etc.
• ThegasconnectionssuppliedwithyourWeber
®
gas barbecue have been designed
and tested to meet 100% CSA and ANSI requirements.
m WARNING: Replacement LP tanks must match the regulator
connection supplied with this barbecue.
◆
Liquid Propane Cylinder Requirements
• ChecktobesurecylindershaveaD.O.T.certification(1), and date tested (2) is within
five years. Your LP gas supplier can do this for you.
• AllLPtanksupplysystemsmustincludeacollartoprotectthecylindervalve.
• TheLPcylindermustbea20-lb.sizeapproximately(18¼incheshigh,12¼inchesin
diameter).
• ThecylindershouldbeconstructedandmarkedinaccordancewiththeSpecifications
for LP - Gas Cylinders of the U.S. Department of Transportation (D.O.T.) or the
National Standard of Canada, CAN/CSA-B339, Cylinders, Spheres and Tubes or
Transportation of Dangerous Goods; and Commission, as applicable.
Canadian Liquid Propane Cylinder Requirements
Note: Your retailer can help you match a replacement tank to your barbecue.
• TheLPcylindermustbeconstructedandmarkedinaccordancewiththe
specifications for LP gas cylinders, T.C.
 previous next