Filter
Top Products
Special offers from our partners!
Find Replacement BBQ Parts for 20,308 Models. Repair your BBQ today.
Page 10 Cal Flame 2008 Owner’s Manual
LTR20081044, Rev. A
Operating Your Barbecue
Each time you light the grill, check the following:
Inspect the hose before using the grill. If there is •
excessive abrasion or wear, or if the hose is cut,
it must be replaced prior to using the grill. If you
need a replacement hose, contact your Cal Flame
dealer.
Ensure the area around the barbecue is clear of •
ammable substances such as gasoline, yard de-
bris, wood, etc.
Ensure there is no blockage of the airow through •
the vent space located below the face of the unit.
Ensure the burner ames burn evenly along both •
sides of each burner with a steady ame (mostly
blue with yellow tipping). If burner ames are not
normal, check the orice and burner for insects or
insect nests.
Ensure the in-line gas valve is always shut OFF •
when the barbecue is not in use.
Do not operate the side burner with its cover closed •
or the back burner with its cover installed.
Electronically Lighting the Grill and Infra-
red Burners
Open the hood.1.
Keep your face as far away from the burners as pos-2.
sible.
Rapidly rotate the burner knob counter clockwise 3.
past the light position to HIGH. You will hear a loud
click as the electronic lighter produces a spark.
Listen for the sound of the gas igniting. If the burner 4.
does not light on the rst try, repeat immediately.
If the burner does not light after three attempts, turn 5.
the control knobs to the OFF position. Wait ve min-
utes until the gas clears before attempting to light it
again.
Repeat the procedure or try the manual lighting pro-6.
cedure below.
Upon successful lighting, repeat the process on the 7.
other burners you wish to light.
To shut off the burners, rotate the knob and turn to 8.
OFF. It is normal to hear a popping sound when the
burners are turned off.
Lighting the Grill
Manually Lighting the Grill and Infrared
Burners
WARNING: Do not use standard matches or cigarette
lighters to perform match lighting procedures. Serious
burns can occur and lighters can explode.
Open the hood.1.
If you have just attempted to light the burner, allow 2.
ve minutes for any accumulated gas to dissipate.
Slide out the drip tray from the grill.3.
Keep your face as far away from the burners as pos-4.
sible.
Light and insert a long stem match, holding it near 5.
the burner ports.
Push in and turn the control knob just past the LIGHT 6.
position to HIGH.
Listen for the sound of the gas igniting. If the burner 7.
does not light after ve seconds, turn the control
knobs to the OFF position. Wait ve minutes until
the gas clears before attempting to light it again.
If the burner does not light after several attempts see 8.
Troubleshooting Guide in the back of this manual.