Filter
Top Products
Special offers from our partners!
Find Replacement BBQ Parts for 20,308 Models. Repair your BBQ today.
Page 16 2007 Barbecue Grill and Cart Owner’s Manual
LTR20071038, Rev. B
Operating Your Barbecue
Each time you light the grill, check the following:
Inspect the hose before using the grill. If there is
excessive abrasion or wear, or if the hose is cut,
it must be replaced prior to using the grill. If you
need a replacement hose, contact your Cal Flame
dealer.
Ensure the area around the barbecue is clear of
ammable substances such as gasoline, yard
debris, wood, etc.
Ensure there is no blockage of the airow through
the vent space located below the face of the unit.
When using propane gas:
Keep the special ventilation openings in
the enclosure free and clear of debris.
•
•
•
•
•
If connected to a propane cylinder,
carefully inspect the rubber hose attached
to the regulator before each use.
Ensure the propane cylinder, regulator,
and rubber hose are installed in a location
not subject to heating above 125º F (51º
C).
Ensure the burner ames burn evenly along both
sides of each burner with a steady ame (mostly
blue with yellow tipping). If burner ames are not
normal, check the orice and burner for insects or
insect nests.
Ensure the in-line gas valve or gas cylinder valve
is always shut OFF when the barbecue is not in
use.
Do not operate the side burner with its cover
closed or the back burner with its cover installed.
•
•
•
•
•
Electronically Lighting the Grill and
Infrared Burners
Open the hood.
Keep your face as far away from the burners as
possible.
Rapidly rotate the burner knob counter clockwise
past the light position to HIGH. You will hear a loud
click as the electronic lighter produces a spark.
Listen for the sound of the gas igniting. If the burner
does not light on the rst try, repeat immediately.
1.
2.
3.
4.
If the burner does not light after three attempts,
turn the control knobs to the OFF position. Wait ve
minutes until the gas clears before attempting to
light it again.
Repeat the procedure or try the manual lighting
procedure below.
Upon successful lighting, repeat the process on the
other burners you wish to light.
To shut off the burners, rotate the knob and turn to
OFF. It is normal to hear a popping sound when the
burners are turned off.
5.
6.
7.
8.
Lighting the Grill
Manually Lighting the Grill and Infrared
Burners
WARNING: Do not use standard matches or cigarette
lighters to perform match lighting procedures. Serious
burns can occur and lighters can explode.
Open the hood.
If you have just attempted to light the burner, allow
ve minutes for any accumulated gas to dissipate.
Slide out the drip tray from the grill.
Keep your face as far away from the burners as
possible.
1.
2.
3.
4.
Light and insert a long stem match, holding it near
the burner ports.
Push in and turn the control knob just past the
LIGHT position to HIGH.
Listen for the sound of the gas igniting. If the
burner does not light after ve seconds, turn
the control knobs to the OFF position. Wait ve
minutes until the gas clears before attempting to
light it again.
If the burner does not light after several attempts
see Troubleshooting Guide in the back of this
manual.
5.
6.
7.
8.