Filter
Top Products
Special offers from our partners!
Find Replacement BBQ Parts for 20,308 Models. Repair your BBQ today.
5
The pressure regulator and hose assembly with the Type 1 fitting supplied
with the appliance must be used. Do not use another hose and regulator
assembly other than the one supplied with the grill or a Coleman®
replacement pressure regulator assembly. The pressure regulator and
hose assembly provided is factory set at an outlet pressure of 11 inches
water column (1/2 psi).
• Keep the small vent hole in the regulator clean of dirt and debris
(see item [G], Fig. 1).
• Consult your L.P. gas dealer if you think the regulator is not working
properly.
WARNING
• DO NOT attempt to adjust the regulator as this could create a
situation causing personal injury or property damage.
WARNING
During assembly of the grill and when attaching or replacing the
L.P. gas cylinder, insure that the gas supply hose is free of kinks
and/or damage and is at least 3 inches away from hot surfaces
such as the grill housing.
Hose and Regulator
Transporting the Refillable Cylinder
• Transport only one refillable cylinder at a time.
• Transport the cylinder in an upright and secure manner with a control
valve turned off and the cap in place.
• DO NOT transport the cylinder in the passenger compartment, unless
you have an open window ventilation.
• DO NOT leave the cylinder in direct sunlight or in a high heat area such
as a closed car trunk. High heat areas could cause the relief valve to
vent gas.
• Use a cylinder cap on the cylinder valve outlet during transport and when
the cylinder is not connected to the grill.
• Keep the cylinder valve closed when not in use.
• Take the cylinder directly home after it has been filled.
The Type 1 connection system has the following features:
1. The system will not allow gas to flow until a positive connection has
been made.
NOTE: The cylinder control valve must be turned off before any
connection is made or removed.
2. The system has a thermal element that will shut off the flow of gas in
the event of a fire.
3. The system has a flow limiting device which, when activated, will limit
the flow of gas to 10 cubic feet per hour.
4. NEVER use grill without leak testing this connection.
WARNING
Handle a full cylinder with care. Gas is under high pressure.
DANGER
• NEVER store a spare L.P. gas supply cylinder under the grill body
or inside the grill enclosure or in the vicinity of any heat producing
appliance. (Fig. 3)
• NEVER fill the cylinder beyond 80% full.
Failure to follow this information exactly could result in an explosion
and/or fire causing death or serious injury.
Transporting the Refillable Cylinder
(continued)
Fig. 3
REPRESENTATIVE ILLUSTRATION