Filter
Top Products
Special offers from our partners!
Find Replacement BBQ Parts for 20,308 Models. Repair your BBQ today.
4
S5
Natural Gas Grills
NATURAL gas grills do not have a pressure regulator. Broilmaster Natural gas grills operate at a manifold
pressure of 7 inches water column.
For NATURAL gas grills, contact your local gas company to have a gas supply line installed for the grill. For
NATURAL gas grills installed on a cart, use Broilmaster’s NG12 twelve foot flexible hose and quick disconnect
kit to connect the grill to a pre-installed gas supply line.
All Grills
Check for gas leaks, after connecting a PROPANE gas cylinder, when a cylinder has not been used recently,
or when a grill is being used for the first time. Use soapy water to check for leaks. Refer to CHECKING FOR
LEAKS at the end of the Installation section.
CAUTION: DO NOT USE CANDLES, MATCHES OR OTHER IGNITION SOURCES WHEN CHECKING FOR
LEAKS. GASES ARE VERY FLAMMABLE AND, IN CERTAIN CONCENTRATIONS, EXPLOSIVE.
CHECKING FOR LEAKS WITH AN OPEN FLAME MAY LEAD TO FIRE, EXPLOSION OR PERSONAL
INJURY.
DO NOT use grill until all leaks are repaired. Always turn gas OFF at the valve on the PROPANE gas cylinder
or, for NATURAL gas, at the supply line shutoff valve when grill is not in use.
Inspect grill’s hose before each use of the grill. If there is excessive wear, or the hose is cut, it must be replaced.
Replace only with the hose assembly specified by the repair parts list or as specified by Broilmaster.
GRILL
LOCA
TION
This grill was designed for outdoor use and should not be used in any building, garage or other enclosed area,
nor is it intended for use in or on any recreational vehicle or boat.
Never use the grill under combustible materials. (carport, covered porch, patio umbrella, etc.)
Minimum clearance from sides of grill to combustible materials (walls, fences, etc.) must be at least 16 inches.
Minimum clearance from back of grill must not be less than 18 inches.
CAUTION:
IF THIS GRILL IS INSTALLED AND OPERATED AT CLEARANCES LESS THAN THOSE
SPECIFIED BY THESE INSTRUCTIONS, THE POSSIBILITY OF A FIRE, PROPERTY DAMAGE OR
PERSONAL INJURY MAY EXIST.
CAUTION:
DO NOT INSTALL OR USE THIS GRILL IN ANY AREA WHERE EXPLOSIVE MATERIALS SUCH
AS GASOLINE OR OTHER FLAMMABLE VAPORS AND LIQUIDS ARE BEING USED OR STORED, THE
FLAME PRODUCED BY THE GRILL IS EXPOSED AND FLAME CONTACT WITH ANYTHING EXPLOSIVE
OR FLAMMABLE WILL RESULT IN EXPLOSION OR FIRE.
Keep area around grill clear. Do not obstruct grill’s combustion and ventilation air flow.
Keep the ventilation opening(s) of the cylinder enclosure free and clear of debris.
Make sure grill is level prior to use.
ASSEMBLY AND INSTALLATION INSTRUCTIONS
All Broilmaster grills require some assembly and installation. Some models require more than others. Some of the following
assembly and installation instructions do not pertain to all grill models. Some grill models come equipped with accessories
(i.e. side burner, cart, etc.) which were assembled and installed at the factory. Some grill models come with accessories
(i.e. cart) which are ready to be assembled and installed. Follow the instructions provided with the accessory to complete
it’s installation on a specific grill model.
PREP
ARATION
1. Before assembling the grill determine which post or cart the grill will be mounted on. See the enclosed “GRILL
MOUNTING” sheet for mounting options. Obtain and assemble the desired mount (post or cart) per instructions
furnished with it.
NOTE:
If grill is to be mounted on an in-ground post, the post shall be protected against corrosion as warranted by
soil conditions. Corrosion protection shall be provided as needed with a suitable coating to retard the effects of
corrosion conditions existing in local areas.