Filter
Top Products
Special offers from our partners!
Find Replacement BBQ Parts for 20,308 Models. Repair your BBQ today.
• Unit is for outdoor use only.
• Never use inside enclosed areas such as patios, garages, buildings or tents.
• Never use inside recreational vehicles or on boats.
• Never operate unit under overhead construction such as roof coverings, carports, awnings, or
overhangs.
• Never use unit as a heater.
• Maintain a minimum distance of 10ft (3m) from overhead construction, walls, rails or other
structures.
• Keep a minimum 10ft (3m) clearance of all combustible materials such as wood, dry plants,
grass, brush, paper, or canvas.
• Keep appliance clear and free from combustible materials such as gasoline and other fl ammable
vapors and liquids.
• Use unit on a level, non-combustible, stable surface such as dirt, concrete, brick or rock.
• Keep children and pets away from unit at all times. Do NOT allow children to use unit.
• Unit has an open fl ame. Keep hands, hair, and face away from burner fl ame. Do NOT lean over
burner when lighting. Loose hair and clothing may catch fi re.
• Allow unit to cool below 115°F (46°C) before moving or storing.
• Avoid bumping or impacting unit.
• This unit is HOT while in use and during cooling process. Wear protective gloves/mitts.
• Use of alcohol, prescription or non-prescription drugs may impair user’s ability to properly
assemble or safely operate unit.
• Never use glass, plastic or ceramic cookware in unit.
• Do NOT allow anyone to conduct activities around unit during or following its use until it has
cooled.
• Accessory attachments not supplied by Masterbuilt Manufacturing, Inc. are not recommended.
• Never use unit for anything other than its intended use. This unit is NOT for commercial use.
• Use in accordance with local, state and federal fi re codes.
GENERAL WARNINGS AND SAFETY INFORMATION
GENERAL WARNINGS AND SAFETY INFORMATION
• Use 20LB (9kgs) gas cylinder that has protective collar (cylinder not included with unit).
• Installation of unit must conform with local codes or in the absence of local codes, with National
Fuel Gas Code, ANSIZ223.1/NFPA 54, Storage and Handling of Liquefi ed Petroleum Gasses,
ANSI/NFPA 58 or CSA B149.1, Natural Gas Installation Code; Propane Storage and Handling, CSA
B149.2; or the Standard for Recreational Vehicles, ANSI A119.2/NFPA 1192; and Recreational
Vehicle Code, CSA Z240 RV Series as applicable.
• LP gas cylinder being used must be constructed and marked in accordance with specifi cations
for LP gas cylinders of the US Department of Transportation (DOT) or the Standard for Cylinders,
Spheres and Tubes for the Transportation for Dangerous Goods, CAN/CSA-B339.
• Always perform soapy water test (see “Soapy Water Test Instructions” in this manual)
EVERY TIME you use unit.
• Before each use check all nuts, screws and bolts to make sure they are tight and secure.
• Before each use inspect gas hose for signs of damage.
• Always disconnect gas cylinder from unit when not in use.
• Never attach/disconnect gas cylinder, move or alter gas fi ttings when unit is in operation.
• Never use gas cylinder if there is evidence of dents, gouges, bulges, fi re damage, erosion,
leakage, excessive rust, or other forms of visible external damage. This may be hazardous and
cylinder should be taken to a liquid propane supplier to be checked.
• Regulator and hose assembly supplied with unit MUST be used. For replacement parts, if
needed, contact Masterbuilt Customer Service at 1-800-489-1581.
• When lighting burner remove all smoker parts to prevent explosion from gas build up.
• If ignition does not take place within fi ve seconds using ignitor button, turn gas control valve to
off position and wait fi ve minutes and repeat lighting procedures.
• Keep fuel supply hose away from unit while in operation.
• Keep fuel supply hose away from any heated surface.
• Do NOT obstruct fl ow of combustion and ventilation. Keep ventilation openings of cylinder
enclosure free and clear of debris.
• When use is complete, always turn regulator control valve OFF fi rst, then gas cylinder valve OFF.
• Gas MUST be turned off at the supply cylinder when not in use.
• Do NOT store spare LP gas cylinder under or near unit. Gas cylinder safety relief valve may
overheat allowing gas to release causing fi re which may cause death or serious injury.
• Never fi ll cylinder over 80% full or cylinder may release gas causing fi re which may cause death
or serious injury.
• If you smell, hear or see gas escaping, immediately get away from gas cylinder and call the Fire
Department. Fire may cause death or serious injury.
• Place a dust cap on cylinder valve outlet whenever cylinder is not in use. Only install dust cap
provided with cylinder. Other caps or plugs may cause leaks.
• Cylinder MUST be stored outdoors, out of children’s reach and must NOT be stored in a building,
garage, or any other enclosed area.
• This appliance is not for frying turkeys.
1
2
DANGER DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open fl ame.
3. Open/remove door.
4. If odor continues, keep away from the
appliance and immediately call your
Fire Department.
1. Never operate this appliance unattended.
2. Never operate this appliance within 10 feet
(3m) of any structure, combustible material
or other gas cylinder.
3. Never operate this appliance within 25 feet
(7.5m) of fl ammable liquids.
4. If fi re should occur keep away from appliance
and immediately call your fi re department.
Do not attempt to extinguish an oil/grease
fi re with water.
FAILURE TO FOLLOW THESE INSTRUCTIONS COULD RESULT IN FIRE, EXPLOSION OR BURN
HAZARD, WHICH COULD CAUSE PROPERTY DAMAGE, PERSONAL INJURY OR DEATH.