Filter
Top Products
Special offers from our partners!
Find Replacement BBQ Parts for 20,308 Models. Repair your BBQ today.
Question:
Can I convert my grill from one fuel type to another in
other words from LPG to NG or vice versa?
Answer:
No, your gas grill is manufactured to exact specifications
and is certified for LPG (Liquid Propane Gas) or NG
(Natural Gas) use only. For your safety, conversion kits
are not available, nor will we sell or otherwise provide
parts or information to be used to convert your grill. Any
attempt to convert your grill is dangerous and will void
your warranty.
Question:
Are the serial and model numbers of my grill listed
somewhere for reference?
Answer:
The serial and model numbers are listed on a silver
CSA label placed on the grill. Depending on the grill
model, the silver CSA label will be located on the left or
right side bowl panel underneath the side shelf,
underneath the right side of the control panel, outside
left or right of control panel or on the back of the grill
cabinet.
Question:
My grill will not light properly. Why?
Answer:
Try this procedure:
1. Turn gas off at source and turn Control Knobs OFF.
Wait at ]east 5 minutes for gas to clear, then retry.
2. ]f your grill still falls to light, turn the Burner Control
Knob(s) and gas source OFF and conduct a leak test
of ALL gas connections and gas sources as
explained in the Use and Care section of this manual.
3. If no leaks are detected, wait 5 minutes for any gas to
clear and repeat the lighting procedure.
Question:
If my ignitor or battery is not working how can I light
my grill manually? And -Why would I need the silver
lighting stick that hangs from the side of my grill?
Answer:
If your ignition fails to work or your battery needs
replacing, you can light your grill through the Lighting
Hole on the side of the grill bowl using the Manual
Lighting Stick that hangs from the side of your grill. The
Lighting Stick is designed to hold a paper match and
allows you to safely insert a match through the Lighting
Hole without getting close to the Burner. Never remove
the Cooking Grids or Savor Plates ® and attempt to light
the grill from above. To light your gas grill manually,
insert a paper match into the Manual Lighting Stick and
follow steps 1 through 6 of the Basic Lighting
Procedures. Then, light the match and place it through
the Lighting Hole on the left side of the grill (location of
hole varies by grill model). Turn the nearest main
Burner Control Knob to the High setting to release gas.
The Burner should light immediately.
Question:
Sometimes I hear a humming sound coming from my
regulator. What causes this? And- My grill has a low
flame and sometimes will not light. Why?
Answer:
]he humming sound is gas flowing through the
regulator. A low volume of sound is normal and will not
interfere with the operation of your grill. Loud or
excessive regulator humming and/or low flow and
intermittent lighting may be caused by the regulator's
excess gas flow device. Opening the tank valve all the
way or too quickly is what triggers the regulator's
safety device to restrict gas flow, preventing excess
gas flow to your grill. Lighting the main Burner farthest
from the fuel source every time will help eliminate air
pockets in the manifold. Note: This procedure should
be done every time a new LP Gas tank is connected to
your grill.
[] Turn all Control Knobs to the OFF position.
[] Turn off the LP Gas tank at the tank valve.
[] Disconnect regulator from LP Gas tank.
[] Let unit stand for 5 minutes.
[] Reconnect regulator to the LP Gas tank.
[] Open grill Lid (or Side Burner Lid if you are lighting
the Side Burner)
[] Turn the tank valve slowly 1/4of one turn.
[] Light the left main Burner.
[] Turn the tank valve slowly one more _¼of one turn
for ½ of one complete turn.
[] Continue to light Burners moving towards the tank.
[] Do not turn tank valve more than ½ of one turn.
Question:
Where do I use my grill for safer operation and
better performance?
Answer:
[] Strong winds and low temperatures can affect the
heating and performance of your gas grill so
factor in these elements when positioning your
grill outdoors for cooking.
[]
[]
[]
[]
Use your grill at least 3 feet away from any wall or
surface.
Use your grill at least 3 feet away from
combustible objects that can melt or catch fire
(such as vinyl or wood siding, fences and
overhangs) or sources of ignition including pilot
lights on water heaters and live electrical
appliances.
Never use your gas grill in a garage, porch, shed,
breezeway or any other enclosed area.
Never obstruct the flow of ventilation air around
your gas grill housing.
A-3