Filter
Top Products
Special offers from our partners!
Find Replacement BBQ Parts for 20,308 Models. Repair your BBQ today.
Do not use a POL transport plug
(plastic part with external threads)!
It will defeat the safety feature
of the valve.
7
Straight
Hold coupling nut and regulator
as shown for proper connection
to LP tank valve.
6.
An additional one-half to three-
quarters turn is required to complete the
connection. Tighten by hand only – do not use
tools.
NOTE:
do not use this
regulator!
Turn the coupling nut clockwise and tighten to a full
solid stop. The regulator will seal on the back-
check feature in the LP tank valve, resulting in
some resistance.
If you cannot complete the connection, disconnect
regulator and repeat steps 5 and 6. If you are still
unable to complete the connection,
5. Hold regulator and insert nipple into LP tank valve.
Hand-tighten the coupling nut, holding regulator in
a straight line with LP tank valve so as to not cross-
thread the connection.
Nipple has to be centered
into the LP tank valve.
WARNING
• Never attempt to attach this grill to the self-
contained LP gas system of a camper trailer
or motor home.
• Do not use grill until leak-tested.
DANGER
• Do not insert any tool or foreign objects into
the valve outlet or safety relief valve. You may
damage the valve and cause a leak. Leaking
propane may result in explosion, fire, severe
personal injury, or death.
• If a leak is detected at any time, STOP and call
the fire department.
• If you cannot stop a gas leak,
close LP tank valve and call LP gas supplier
or your fire department!
immediately
Safety Tips
s
s
s
s
s
s
s
s
s
s
Before opening LP tank valve, check the
coupling nut for tightness.
When grill is not in use, turn off all control knobs
and LP tank valve.
Never move grill while in operation or still hot.
Use long-handled barbecue utensils and oven
mitts to avoid burns and splatters.
Maximum load for sideburner and side shelf is
10 lbs.
Do not use a cooking pot larger than 9” on the
sideburner.
A soup can or grease cup be attached to
grease clip/grease tray and emptied after each
use. Do not remove soup can/grease cup until
grill has completely cooled.
If you notice grease or other hot material
dripping from grill onto valve, hose or regulator,
turn off gas supply at once. Determine the
cause, correct it, then clean and inspect valve,
hose and regulator before continuing. Perform a
leak test.
The regulator may make a humming or whistling
noise during operation. This will not affect safety
or use of grill.
If you have a grill problem see the
.
must
"Troubleshooting Section"