Filter
Top Products
Special offers from our partners!
Find Replacement BBQ Parts for 20,308 Models. Repair your BBQ today.
14
Cleaning The Performance and Advantage Burner Assembly
Follow these instructions to clean and/or replace parts of burner assembly or if you have trouble igniting the
grill.
1.
2. Remove cooking grids and vaporizer tents.
3. Remove two pal nuts, carry-over tube and burners.
4. Under grill remove grease pan and tray. Clean with soap and water.
5. Disconnect battery and under console disengage ignitor wire.
6. Wipe ceramic electrode with rubbing alcohol and cloth.
7. Clean carry-over tube and burners exterior with soap and water. Lay burners on flat surface, insert
garden hose (preferably with nozzle), into burner tubes forcing water through tubes. Make sure water
comes out of every porthole. Open clogged portholes with a thin wire. and
examine porthole. Due to normal wear and corrosion some portholes may become enlarged, if so
replace burner. If any horizontal cracks appear from porthole to porthole or large holes (other than
portholes) are found replace burner.
8. If grill is to be stored, coat burners lightly with cooking oil. Wrap in protective cover to keep insects out.
If not storing use following steps.
9. Attach ignitor wire to electrode.
10. Reposition cooking grids and vaporizer tents. Place clean grease tray and pan into grill bottom.
11. Before cooking again on grill, perform a and .
Do not use ceramic briquets or charcoal in your grill.
Performance and Advantage Series grills are equipped with a removable grease tray. Although grease
will drain from the grease tray to the grease cup provided, food particles and debris may accumulate in the
bottom and should be removed after cooking 5 to 10 times. This can easily be done by sliding the grease
tray out of the rear of the unit. Make sure in replacing the tray to push it all the way forward.
Turn gas off at control knobs and LP tank.
Shake out excess water
VERY IMPORTANT: Burner tubes must engage valve openings as shown (A).
Cleaning the Performance and Advantage Grease Tray
Replace battery.
“Leak Test” “Burner Flame Check”
s
CAUTION
• Handles close to the lid can become hot. Lift
handle in the middle where it remains cool.