Filter
Top Products
Special offers from our partners!
Find Replacement BBQ Parts for 20,308 Models. Repair your BBQ today.
3
WARNING
Use caution when operating the door of the smoker while in operation. Keep hands, face and body safe from
hot steam or flare-ups. Protect your nose and mouth from smoker inhalation.
DO NOT wear loose clothing while operating the smoker. Tie back long hair while operating the smoker.
ALWAYS wear fully-covering shoes while operating the smoker.
Allow the smoker and its components to cool completely before conducting any routine cleaning or mainte-
nance.
NEVER use glassware, plastic or ceramic cookware on or in your smoker.
NEVER operate the smoker without water in the water bowl. NEVER allow the water to completely evapo-
rate. Check the water level at least every 2 hours. A sizzling sound may indicate a low water level. Follow
instructions in this manual for adding water while operating.
When using flavoring wood, add a sufficient amount prior to operation to avoid having to add wood while
operating. Adding while operating may splash hot water and cause serious injury.
Use of accessories not intended for this smoker is not recommended and may lead to injury or property
damage.
An LP cylinder not connected for use should not be stored in the vicinity of the smoker or any other appli-
ance. DO NOT store spare LP cylinders within 10 feet of the smoker. LP cylinder must be stored outdoors,
out of reach of children. DO NOT store lP cylinders in a building, garage or any other enclosed area.
DO NOT store LP gas cylinders inside or on top of the smoker. Improper storage of cylinders could lead to
explosion, fire and/or personal injury. Cylinders are to be stored outdoors, out of reach of children and must
not be stored in a building, garage or any other enclosed area.
While the smoker is not in use, the gas must be turned off at the supply cylinder.
LP Gases are heavier than air, tend to pool and collect in low-lying areas, are easily ignited and are highly
flammable. Proper care and caution should be employed when dealing with any such fuels.
The smoker should be shut off and all supply valves (on piping or on fuel cylinders) should be closed in the
event that the odor of unburned gas is detected. Do not attempt to use the unit until any gas leaks are fixed
and/or the source of the unburned gas odor is accounted for.
Do not use the smoker if the burner fails to light or fails to remain it. Under such conditions, gas should be
shut off and fuel cylinder should be disconnected.
Use under high wind conditions that result in poor burner operation
such as blowing out and flaring should be avoided. If repositioning
the unit does not improve operation under such wind conditions, the
unit should be shut off.
All installations are to conform to local codes. In the absence of local
codes, installation should conform to the National Fuel Gas Code,
ANSI Z223.1/NFPA 54.
The smoker should be installed with the hose regulator assembly ex-
tended at full length of the hose directly (24” [61 cm] maximum) away
from the burner. When so configured, placement results in maximum
tank to smoker distance. When the smoke is operated, the hose/reg-
ulator and gas tank should be on a line perpendicular to wind direc-
tion. Placing tank closer than 24” (61 cm) to the smoker can overheat
the tank and cause release of propane through relief openings and
can result in tank fire or explosion.
USE CAUTION AND COMMON SENSE WHEN OPERATING YOUR SMOKER.
READ ALL INSTRUCTIONS, WARNINGS AND SAFEGUARDS BEFORE ASSEMBLING AND
OPERATING YOUR SMOKER.
SAVE THESE INSTRUCTIONS