Broilmaster P3SXN-1 Gas Grill User Manual


  Open as PDF
of 52
 
B101525-4-0411 Page 37
1. R3B Grills: Remove cooking grids, briquets and
briquet rack from grill.
2. Blue Flame Burner: Remove blue ame burner
shield and blue ame burner from grill (one (1) 1/4-
20 x 3/4 phillips screw for burner). See Figure 32.
Infrared Burner: Remove ignitor wire, lugs and in-
frared burner from grill (one (1) 1/4-20 x 3/4 phillips
screw for each burner). See Figure 32.
3. Remove LP burner orices marked 1.25 mm for
R3B. Remove LP burner orice marked 1.3 mm
for R3. See Figure 33.
4. Install natural gas burner orice marked 49 into
each orice tting. Apply pipe compound to threads
on orices prior to installation.
5. Blue Flame Burner: Place burner shield and burn-
ers into grill and insert burner tubes over orice
ttings. Secure each burner with one (1) 1/4-20 x
3/4 phillips screw from Step 2.
Infrared Burner: Place infrared burners, ignitor,
and lugs into grill and insert burner tubes over ori-
ce ttings. Secure each burner with one (1) 1/4-
20 x 3/4 phillips screw from step 2.
6. Grasp valve knobs and remove from valves.
7. The low input adjustment screws are located in-
side the two valve stems. Use a small screwdriver
to turn each adjustment screw clockwise 1/4 turn
(90 degrees). When valves are in the "OFF" posi-
tion, the slot in the adjustment screw should be
vertical. See Figure 34.
8. Remove the hose and regulator from the gas con-
nection on grill with adjustable wrench.
9. Connect the grill to the natural gas supply.
Attention: Before lighting your grill check all gas
connections including the adjustment screws in
valve stems for gas leaks with a soapy water mixture.
Caution: Do not use the grill if a gas leak is de-
tected until gas leak is corrected. If a gas leak can
not be stopped, do not use grill. You must contact
a qualied repair person.
10. Push valve knobs onto valves.
11. Apply the completed conversion label adjacent to
the rating plate label on the grill.
Figure 33
LPG
NAT
ADJUSTMENT SCREW
ADJUSTMENT SCREW
Figure 34
R3B
R3
Figure 32
GAS CONVERSION TO NATURAL GAS
 previous next