Weber 54406 Gas Grill User Manual


  Open as PDF
of 120
 
WWW.WebeR.com
®
7
Your Weber
®
gas barbecue is a portable outdoor cooking appliance. With the Weber
®
gas barbecue you can grill, barbecue, roast and bake with results that are difficult to
duplicate with indoor kitchen appliances. The closed lid and Flavorizer
®
bars produce
that “outdoor” flavor in the food.
The Weber
®
gas barbecue is portable so you can easily change its location in your yard
or on your patio. Portability means you can take your Weber
®
gas barbecue with, if you
move.
Liquid Propane (LP) gas supply is easy to use and gives you more cooking control than
charcoal fuel.
• Theseinstructionswillgiveyoutheminimumrequirementsforassemblingyour
Weber
®
gas barbecue. Please read the instructions carefully before using your
Weber
®
gas barbecue. Improper assembly can be dangerous.
• Notforusebychildren.
• Iftherearelocalcodesthatapplytoportablegasgrills,youwillhavetoconformto
them. Installation must conform with local codes or, in the absence of local codes,
with either the National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural Gas and
Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code,
B149.2, or the Standard for Recreational Vehicles, ANSI A 119.2/NFPA 1192, and
CSA Z240 RV Series, Recreational Vehicle Code, as applicable.
• ThepressureregulatorsuppliedwiththeWeber
®
gas barbecue must be used. This
regulator is set for 11 inches of water column (pressure).
• ThisWeber
®
gas barbecue is designed for use with liquid propane (LP) gas only. Do
not use with natural (piped in city) gas. The valves, orifices, hose and regulator are for
LP gas only.
• Donotusewithcharcoalfuel.
• Checkthattheareaunderthecontrolpanelandtheslideoutgreasetrayarefree
from debris that might obstruct the flow of combustion or ventilation air.
• TheareasaroundtheLPcylindermustbefreeandclearfromdebris.
• Replacementpressureregulatorsandhoseassembliesmustbethosespecifiedby
Weber-Stephen Products LLC.
◆
CANADIAN INSTALLATION
These instructions, while generally acceptable, do not necessarily comply with the
Canadian Installation codes, particularly with piping above and below ground. In
Canada, the installation of this appliance must comply with local codes and/or the latest
edition of Standard CAN/CSA-B149.2 (Propane Storage and Handling Code).
◆
OPERATING
m WARNING: Only use this barbecue outdoors in a well-
ventilated area. Do not use in a garage, building, breezeway
or any other enclosed area.
m WARNING: Keep ventilation openings for cylinder enclosure
free and clear from debris.
m WARNING: Your Weber
®
gas barbecue shall not be used
under overhead combustible construction.
m WARNING: Your Weber
®
gas barbecue is not intended to be
installed in or on recreational vehicles and/or boats.
m WARNING: Do not use the barbecue within 24 inches of
combustible materials.
m WARNING: The entire cookbox gets hot when in use. Do not
leave unattended.
m WARNING: Keep electrical supply cord and the fuel supply
hose away from heated surfaces.
m WARNING: Keep the cooking area clear of flammable vapors
and liquids such as gasoline, alcohol, etc., and combustible
materials.
m WARNING: Never store an extra (spare) LP cylinder under or
near the Weber
®
gas barbecue.
m WARNING: The LP cylinder used with your barbecue must
be with a listed OPD (Overfilling Prevention Device) and
a QCC1 or Type 1 (CGA810) cylinder connection. The
cylinder connection must be compatible with the barbecue
connection.
◆
STORAGE AND/OR NONUSE
• ThegasmustbeturnedoffattheliquidpropanecylinderwhentheWeber
®
gas
barbecue is not in use.
• WhentheWeber
®
gas barbecue is stored indoors, the gas supply must be
DISCONNECTED and the LP cylinder stored outdoors in a well-ventilated space.
• LPcylindermustbestoredoutdoorsinawell-ventilatedareaoutofreachofchildren.
Disconnected LP cylinder must not be stored in a building, garage or any other
enclosed area.
• WhentheLPcylinderisnotdisconnectedfromtheWeber
®
gas barbecue, the
appliance and LP tank must be kept outdoors in a well-ventilated space.
• TheWeber
®
gas barbecue should be checked for gas leaks and any obstructions
in the burner tubes before using. (Refer to “MAINTENANCE/ANNUAL
MAINTENANCE”).
• Checkthattheareasunderthecontrolpanelandthedriptrayarefreefromdebris
that might obstruct the flow of combustion or ventilation air.
• TheSpider/Insectscreensshouldalsobecheckedforanyobstructions.(Referto
“MAINTENANCE/ANNUAL MAINTENANCE”).
◆
GeNeRAL INSTRUcTIoNS
 previous next