Filter
Top Products
Special offers from our partners!
Find Replacement BBQ Parts for 20,308 Models. Repair your BBQ today.
if thegrill fallsto light propeNy:
1. Turngasoffatsourceandturnthecontrolknobto
OFF.Waitatleastfiveminutesforgastoclear,
thenretry.
2. Checkgassupplyandconnections.
3. Repeatlightingprocedure.If yourgrillstillfails
to operateproperly,turnthegasoff atsource,
turnthecontrolknobsto OFF,thencheckthe
following:
,, Misaiignmentofburnertubesoverodfices
Correction:Repositionburnertubesoverorifices.
" Obstructioningasline
Correction:Removefuellinefromgrill.Donot
smoke!Opengassupplyforonesecondtoclear
anyobstructionfromfuelline.Closeoffgassupply
atsourceandreconnectfuellinetogrill.
" Pluggedorifice
Correction:Removeburnersfromgrillbypulling
cotterpin(beneathburner)usingascrewdriveror
pliers.Carefullylifteachburnerupandawayfrom
gasvalveorifice.Removetheorificefromgas
valveandgentlyclearanyobstructionwithafine
wire.Thenreinstalla[[orifices,burners,cotter
pinsandcookingcomponents.
ifanobstructionissuspectedingasvalvesor
gasvalvebracket,pleasecallforrepairserviceat
1-800-4-MY-HOME.
" Misalignmentofignitoronburner
Correction:Checkforproperpositionofthe
electrodetipasshownin Figure13.Thegap
betweentheSparkElectrodeTipandSpark
Receivershouldbeapproximately3/16".Adjustif
necessary.Withthegassupplyclosedandall
controlknobssettoOFFpresstheelectric
ignitorcapandcheckforthepresenceofaspark
attheelectrode.
', DisconnectedignitionWires
Correction:Inspectthebnitorjunctionboxfound
behindtheControlPanel.Connectlooseignitor
wirestojunctionboxandtrytolightthegrill.
,, WeakAAbattery
Correction:UnscrewtheignitorCapand
replacethebattery.
. if the gdH still does not light you may need
to purge air from the gas line or reset the
regulator excess gas flow device. Note: This
procedure should be done every time a new
LP gas tank is connected to your grill.
To purge air from your gas line and/or
reset the regulator excess gas flow device:
" Turn the control knobs to the OFF position.
" Turn off the gas at the tank valve.
" Disconnect regulator from LP gas tank.
" Let unit stand for 5 minutes.
" Reconnect regulator to the LP gas tank.
" Turn the tank valve on slowly until 1/4 to
1/2 open.
" Open the Grill Lid or Side Burner Lid.
" Set control knobs to OFF and open the LP
gas tank valve.
" To light grill push and turn the LEFT
control knob to HIGH. To light the Side
Burner turn its control knob to HIGH.
5. if all checks or corrections have been made and
you still have questions about operating your gas
grill, ca[[the Manufacturer's Customer Service
Help[ine 8am z 8pm CST, Monday through Friday at
1-888-317W642.
Should a "FLASH-BACK" fire occur in/or
around the burner tubes, follow the
instructions below. Failure to comply with
these instructions could result in a fire or
expbsion that could cause serious bodily
injury, death, or property damage.
, Shut off gas supply to the gas grill.
, Turn the control knobs to OFF position.
, Put out any flame with a fire extinguisher.
, Open grill Hd.
, Once the grill has cooled down, dean
the burner tubes and burners according
to the cleaning instructions found on
page 19 in this manual
17