Filter
Top Products
Special offers from our partners!
Find Replacement BBQ Parts for 20,308 Models. Repair your BBQ today.
Care and Cleaning
Stainless Steel Outdoor Cooking Center
18
Burner
removal
Ensure the gas supply is off, the knobs are in the
OFF position and all surfaces are cool before
removing a burner.
The grill and range-top burners (on some
models) are cast iron coated with porcelain
enamel. Occasionally it will be necessary to
remove surface rust to ensure proper
performance. Frequency of cleaning will
depend on the climate and location and how
often you use the cooking center. The walls of
the burners are thick so they can withstand many
years of use.
To remove the grill burner, remove the grill
racks, then lift out the lava rock support with
the lava rocks still on the support. Grasp the
burner, pull it up and slightly to the rear of the
unit so the burner head comes off the brass
orifice at the front. Angle the burner sideways
and remove.
To remove the range-top burners (on some
models), remove the top grates. Lift out
aeration pan from around the burners. Lift and
remove the front and rear range-top burners.
The smoker burner can be removed and
cleaned by unplugging the igniter wire and
lifting out the burner.
To reassemble the burners, replace the burner
by sliding the air shutters over the brass orifice,
centering it in the hole. It is extremely important
to center the burner on the orifice properly.
Be careful not to upset the air shutters’ original
position (unless readjusting). Lower the rear of
the burner into the cutouts on the support
channel at the rear of the burner box. Make
sure it is level and does not rock. Replace the
stainless steel radiant tray so that the slots in the
corners of the tray align with the projections on
the top of the burner. Make sure that it sits level
and does not rock.
Light all of the burners and check for proper
flame characteristics. (Do not attempt to light
the burners prior to replacing radiant trays,
grills and aeration pans.) If adjustments are
necessary refer to the Installation Instructions.
Venturi tube
Flash tubes
Igniter
Burner hanger
Lighter
ports
Air shutters
Range-top burner
Grill burner