Filter
Top Products
Special offers from our partners!
Find Replacement BBQ Parts for 20,308 Models. Repair your BBQ today.
466231203 • 11
• A disconnected LP tank in storage or being transported must
have a safety cap installed (as shown). Do not store an LP
tank in enclosed spaces such as a carport, garage, porch,
covered patio or other building. Never leave a LP tank inside a
vehicle which may become overheated by the sun.
• Do not store LP tank in an area where children play.
Leak Testing Valves, Hoses and Regulator
1. Turn all grill control knobs to OFF.
2. Be sure regulator is tightly connected to LP tank.
3. Completely open LP tank valve by turning hand wheel counter
clockwise. If you hear a rushing sound, turn gas off
immediately. There is a major leak at the connection. Correct
before proceeding.
LP Tank Removal, Transport And Storage
• Turn OFF all control knobs and LP tank valve. Turn coupling nut
counter clockwise by hand only - do not use tools to disconnect. Lift
LP tank wire upward off of LP tank collar, lift LP tank up and off of
support bracket. Install safety cap onto LP tank valve. Always use
cap and strap supplied with valve. Failure to use safety cap as
directed may result in serious personal injury and/or
property damage.
LP Tank
Valve
Safety
Cap
Retainer
Strap
• NEVER store a spare LP tank under or near grill or in
enclosed areas.
• Never fill the cylinder beyond 80% full. An overfilled
spare LP tank is hazardous due to possible gas
released from the safety relief valve. The safety relief
valve on a LP tank could activate releasing gas and
cause a fire.
• If you see, smell or hear escaping gas, immediately
get away from the LP tank/grill and call your fire
department.
• All spare LP tanks must have safety caps installed on
the LP tank outlet.
DD
DD
D
ANGERANGER
ANGERANGER
ANGER
4. Brush soapy
solution onto
following
connections:
5. "If growing" bubbles appear,
there is a leak. Close LP tank
valve immediately and retighten
connections. If leaks cannot
be stopped "do not try to
repair." Call for replacement parts.
Order new parts by giving the serial, model number and
name of items needed to the Grill Service Center at
!1-800-241-7548 U.S. or 1-800-387-6057 CAN.
6. Always close LP tank valve after performing leak test by
turning hand wheel clockwise.
Safety Tips
▲▲
▲▲
▲ Before opening LP tank valve, check the coupling nut for
tightness.
▲▲
▲▲
▲ When grill is not in use, turn off all control knobs and LP tank
valve.
▲▲
▲▲
▲ Never move grill while in operation or still hot.
▲▲
▲▲
▲ When moving the grill push it forward, do not pull from
behind.
▲▲
▲▲
▲ Use long-handled barbecue utensils to avoid burns and
splatters.
▲▲
▲▲
▲ Do not remove grease receptacle or tray until grill has
completely cooled.
▲▲
▲▲
▲ If you notice grease or other hot material dripping from grill
onto valve, hose or regulator turn off gas supply at once.
Determine the cause, correct, clean and inspect valve, hose
and regulator before continuing. Perform a leak test.
▲▲
▲▲
▲ The regulator may make a humming or whistling noise
during operation. This will not affect safety or use of grill.
▲▲
▲▲
▲ If you have a grill problem see the "Troubleshooting Section".