Filter
Top Products
Special offers from our partners!
Find Replacement BBQ Parts for 20,308 Models. Repair your BBQ today.
Page 17B100911-3-0806
1/8"
ORIFICE
HOOD
NUT
SUPPLY
TUBE
48
WRENCH
SUPPLY
TUBE
ORIFICE HOOD
HOSE AND REGULA TOR
SUPP LY TUB E
HOSE AND REGULATOR
SUPPLY TUBE
ORIFICE HOOD
Gas Conversion
Propane grills include a conversion kit for natural
gas. If you have a natural grill and wish to convert
it to propane you will need to purchase the optional
conversion kit #BCK195.
Begin by removing all the components from the inside
of your grill. Locate and remove the orifice hoods
mounted on the underside of the grill body, using 2
wrenches as shown. Figure 13.
Gas Conversion
Before installing the natural hoods, inspect them for
damage and note the number stamped on the side. The
correct hood will be marked "48".
The hoods are self-sealing, requiring no additional pipe
sealant. If you wish to use sealant, take care to add it
to the threads only to avoid blocking the orifice.
Thread the hoods onto the supply tubes leaving about
a 1/8" gap between the hood and the locking nut.
Figure 14.
Remove the hose and regulator from the valve.
Replace the components inside of your grill.
Remove the knobs from the valve assembly and locate
the adjustment screws on the inside of the valve stem.
Using a small screw driver, turn the screws clockwise
until screw bottoms, then turn the screws four (4) FULL
turns counterclockwise. Do not back the screws out more
than 4 1/2 turns or a leak may result. Figure 15.
Connect the grill to the natural gas supply.
Important: Before lighting your grill, check the gas
connections and the adjustment screws for leaks using
a soapy water solution.
Caution: Never use this or any gas appliance which
may be leaking gas.
Replace the knobs.
ADJUSTMENT SCREW
VALVE STEM
CONTROL PANEL
OFF
3
HI
OFF
RIGHT
3
HI
LEFT
1
LO
2
LO
2
1
Figure 13
Figure 14
Figure 15
Place the completed conversion label adjacent to the
product identification label, located on the control
panel (26).
NOTE: When converting your grill to Natural gas and
your incoming gas pressure is below 7", a DPA105
regulator kit can be purchased.
Mueller