Brinkmann Two Burner Gas Grill User Manual


  Open as PDF
of 8
 
Step 1
Make sure the regulator knob and control knobs are in
the "OFF" position.
Step 2
Make sure regulator/valve assembly is properly attached
to propane cylinder refer to "Assembly Instructions".
Attach regulator/valve assembly to the side of the
Camping Stove. HAND TIGHTEN ONLY.
Step 3
Prepare a soapy water solution (one part dishwashing
liquid to three parts water) to test for gas leaks in the
assembly hose and connections. Apply a generous
amount of the soapy mixture to the regulator stem, the
entire length of hose and Camping Stove fitting (located
on the right side of stove).
Step 4
With the control knobs in the "OFF" position, open the
regulator valve two full turns (counter-clockwise). Next,
check for bubbles at regulator valve, along the entire
length of hose and at the Camping Stove fitting. DO NOT
LEAVE GAS ON FOR MORE THAN 10 SECONDS. If soapy
mixture starts bubbling, gas is leaking through the
connection or hose. Turn the regulator valve "OFF" and
retighten the connection that is leaking gas. Repeat
procedure with soapy mixture until gas no longer leaks.
NEVER USE A FLAME TO CHECK FOR GAS LEAKS. Turn
the regulator valve "OFF" after each test.
Step 5
Once all gas leaks have been sealed, WAIT AT LEAST 5
MINUTES FOR GAS FUMES TO DISSIPATE BEFORE
LIGHTING THE BURNERS.
Carefully follow "Operating Instructions" to light the
burner and properly operate this unit.
GAS LEAK TESTING
THE GAS LEAK TESTING PROCEDURE MUST BE PERFORMED
EVERY TIME THE CYLINDER IS CONNECTED TO STOVE.
4
Watch for Bubbles
Regulator/Valve
Assembly
WARNING
• Gas leak testing must be performed outdoors in a well ventilated area.
• During the gas leak testing procedure, always keep unit away from open flames, sparks or lit cigarettes.
• Never use a flame to check for gas leaks.
• Always use the regulator valve knob to turn the unit "OFF". The control knobs are used when lighting the burners
and to adjust the flame.
• Never use a unit that has a gas leak. Contact The Brinkmann Corporation’s Customer Service Department for
replacement parts at 1-800-527-0717.
NOTE: Use propane cylinder upright when
possible to prevent flare-ups. Make
sure not to cross-thread fittings
while tightening.
Stove Fitting
Propane Cylinder Valve
 previous next