Filter
Top Products
Special offers from our partners!
Find Replacement BBQ Parts for 20,308 Models. Repair your BBQ today.
Outdoor LP Gas Barbecue Grill Model No. GBT10039L / 0184543
Troubleshooting
Problem Possible Cause Prevention/Cure
Burner will not light using ignitor
(if included)
,0 GAS TANK IS LOW OR EMPTY 2EPLACE ,0 GAS TANK
,0 GAS LEAK &OLLOW h#HECKING FOR ,EAKSv INSTRUCTIONS IN THE OWNERS MANUAL
7IRES OR ELECTRODE COVERED WITH COOKING RESIDUE #LEAN WIRE ANDOR ELECTRODE WITH RUBBING ALCOHOL
%LECTRODE AND BURNERS ARE WET 7IPE DRY WITH CLOTH
%LECTRODE CRACKED OR BROKEN SPARKS AT CRACK 2EPLACE ELECTRODE PLEASE CALL OUR #USTOMER #ARE AT
Wire loose or disconnected
2ECONNECT WIRE OR REPLACE ELECTRODEWIRE ASSEMBLY PLEASE CALL OUR #USTOMER
#ARE AT
7IRE IS SHORTING SPARKING BETWEEN IGNITOR AND ELECTRODE
2EPLACE IGNITOR WIREELECTRODE ASSEMBLY PLEASE CALL OUR #USTOMER #ARE AT
Bad ignitor 2EPLACE IGNITOR PLEASE CALL OUR #USTOMER #ARE AT
Burner will not light with match
.O GAS FLOW
#HECK IF ,0 GAS TANK IS EMPTY
! )F EMPTY REPLACE
" )F ,0 GAS TANK IS NOT EMPTY REFER TO h3UDDEN DROP IN GAS FLOW OR REDUCED
FLAME HEIGHTv
,0 GAS TANK IS LOW OR EMPTY 2EPLACE ,0 GAS TANK
,0 GAS LEAK &OLLOW h#HECKING FOR ,EAKSv INSTRUCTIONS IN THE OWNERS MANUAL
Coupling nut and regulator not fully connected
Turning the coupling nut about one-half to three quarters additional turn until
SOLID STOP 4IGHTEN BY HAND ONLYDO NOT USE TOOLS
/BSTRUCTION OF GAS FLOW #LEAR BURNER TUBES PER CLEANING INSTRUCTION ON WWWBLUERHINOCOM
3PIDER WEBS OR INSECT NEST IN VENTURI #LEAN VENTURI AND BURNER TUBE PER CLEANING INSTRUCTION ON WWWBLUERHINOCOM
Burner ports clogged or blocked #LEAN BURNER PORTS PER CLEANING INSTRUCTION ON WWWBLUERHINOCOM
Sudden drop in gas flow or reduced flame height
/UT OF GAS 2EPLACE ,0 GAS TANK
%XCESS FLOW VALVE TRIPPED SAFETY DEVICE MAY HAVE BEEN
ACTIVATED
4URN REGULATORCONTROL KNOB TO h,/#+/&&v
7AIT SECONDS AND LIGHT GRILL
)F FLAMES ARE STILL TOO LOW RESET THE EXCESSIVE FLOW SAFETY DEVICE
A 4URN REGULATORCONTROL KNOB h,/#+/&&v
B 2EMOVE ,0 GAS TANK
C 7AIT MINUTE
D !TTACH ,0 GAS TANK
E 0ERFORM A LEAK CHECK PER h#HECKING FOR ,EAKSv INSTRUCTIONS IN THE OWNERS
manual
F ,IGHT GRILL PER h,IGHTING )NSTRUCTIONSv INSTRUCTIONS IN THE OWNERS MANUAL
Irregular flame pattern, flame does not run the
full length of burner
Burner ports are clogged or blocked
#LEAN BURNER PORTS PER CLEANING INSTRUCTION ON WWWBLUERHINOCOM
Flame is yellow or orange
.EW BURNER MAY HAVE RESIDUAL MANUFACTURING OILS "URN GRILL FOR MINUTES ON h()'(v WITH THE LID CLOSED
3PIDER WEBS OR INSECT NEST IN VENTURI #LEAN VENTURI PER CLEANING INSTRUCTION ON WWWBLUERHINOCOM
&OOD RESIDUE GREASE ETC #LEAN BURNER PER CLEANING INSTRUCTION ON WWWBLUERHINOCOM
0OOR ALIGNMENT OF VALVE TO BURNER VENTURI !SSURE BURNER VENTURI IS PROPERLY ENGAGED WITH VALVE
Flame blow out
(IGH OR GUSTING WINDS $O NOT USE GRILL IN HIGH WINDS
,OW ON ,0 GAS 2EPLACE ,0 GAS TANK
%XCESS FLOW VALVE TRIPPED SAFETY DEVICE MAY HAVE BEEN
ACTIVATED
2EFER TO h3UDDEN DROP IN GAS FLOW OR REDUCED FLAME HEIGHTv
Flare-up
Grease buildup
2EMOVE AND CLEAN ALL GRILL PARTS PER h#LEANING AND #AREv INSTRUCTIONS IN THE
OWNERS MANUAL
%XCESS FAT IN MEAT Trim fat from meat before grilling
%XCESSIVE COOKING TEMPERATURE !DJUST LOWER COOKING TEMPERATURE
Persistent grease fire
Grease trapped by food buildup around burner system
4URN CONTROL KNOB TO h,/#+/&&v
,EAVE LID IN CLOSED POSITION AND LET FIRE BURN OUT
!FTER GRILL COOLS REMOVE AND CLEAN ALL PARTS PER h#LEANING AND #AREv
INSTRUCTIONS IN THE OWNERS MANUAL
Flashback (fire in burner tube(s))
Burner and/or burner tubes are blocked
#LEAN BURNER ANDOR BURNER TUBE PER CLEANING INSTRUCTION ON WWWBLUERHINO
com
Inside of lid is peeling (like paint peeling)
The lid is stainless steel, not painted
Baked on grease buildup has turned to carbon and is flaking off, clean
THOROUGHLY PER h#LEANING AND #AREv INSTRUCTIONS IN THE OWNERS MANUAL
The lid is coated/painted
This can be from baked on grease buildup, that has turned into carbon and is
FLAKING OFF
#LEAN THOROUGHLY PER h#LEANING AND #AREv INSTRUCTIONS IN THE OWNERS MANUAL
After cleaning, if you can see steel, please call out Customer Care at
For more assistance please visit us online at www.bluerhino.com or call 1.800.762.1142.