Uniflame GAD860SP Outdoor Fireplace User Manual


  Open as PDF
of 12
 
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
PAGENO
9
C4URNCONTROLKNOBCOUNTERCLOCKWISETO ,/7
D2EMOVELONGMATCHLONGBUTANELIGHTERONCELIT
CAUTION: After Lighting - Using a shovel and heat resistant gloves,
carefully move the lava rocks back to their proper position, being
careful to avoid the flame.
!FTERLIGHTINGOBSERVETHEBURNERFLAMEMAKESUREALLBURNERPORTSARELITANDFLAMEHEIGHT
MATCHESILLUSTRATION&IGURE
!DJUSTFLAMETODESIREDHEIGHTWITHTHECONTROLKNOB
Caution: If burner flame goes out during operation, immediately turn
the control knob
(OFF) and open lid to let the gas clear for 5 minutes
before re-lighting.
Turning Off
4URN,0GASTANKVALVETOh#,/3%$v
4URNALLCONTROLKNOBSTOTHEh/&&
vPOSITION
Note: !hPOOFvSOUNDISNORMALASTHELASTOFTHE,0GASISBURNED
$ISCONNECT,0GASTANKPERh$ISCONNECT,0'AS4ANKvINSTRUCTIONS
Cleaning and Care
CAUTION:
1. All cleaning and maintenance should be done when outdoor
fireplace is cool and with the fuel supply disconnected.
2. DO NOT clean any outdoor fireplace part in a self cleaning oven. The
extreme heat will damage the finish.
3. Do not enlarge valve orifices or burner ports when cleaning the
valves or burners.
Notices
1. This outdoor fireplace should be thoroughly cleaned and inspected on a regular basis.
2. Abrasive cleaners will damage this product.
3. Never use oven cleaner to clean any part of outdoor fireplace.
Before Each Use:
+EEPTHEOUTDOORFIREPLACEAREACLEANANDFREEFROMANYCOMBUSTIBLEMATERIALSGASOLINEAND
OTHERFLAMMABLEVAPORSANDLIQUIDS
$ONOTOBSTRUCTTHEFLOWOFTHECOMBUSTIONOF,0ANDTHEVENTILATIONAIR
+EEPTHEVENTILATIONOPENINGSOFTHE,0GASTANKAREAFREEANDCLEARFROMDEBRIS
6ISUALLYCHECKTHEBURNERFLAMESTOMAKESUREYOUROUTDOORFIREPLACEISWORKINGPROPERLY
3EESECTIONSBELOWFORPROPERCLEANINGINSTRUCTIONS
#HECKALLGASCONNECTIONSFORLEAKS
#HECKCOMPONENTSFORANYSIGNSOFDAMAGEORRUST
#HECKANDCLEANTHEBURNERVENTURITUBESFORINSECTSANDINSECTNESTS!CLOGGEDTUBECAN
LEADTOAFIREBENEATHTHEOUTDOORFIREPLACE
)FDAMAGETOANYCOMPONENTISDETECTEDDO./4OPERATEUNTILREPAIRSAREEXECUTED
Cleaning Surfaces
7IPESURFACESCLEANWITHMILDDISHWASHINGDETERGENTORBAKINGSODAMIXEDWITHWATER
&ORSTUBBORNSURFACESUSEACITRUSBASEDDEGREASERANDANYLONSCRUBBINGBRUSH
2INSECLEANWITHWATER
!LLOWTOAIRDRY
Before Storing
4URNCONTROLKNOBTO /&&AND,0GASTANKVALVETOh#,/3%$v
#LEANALLSURFACES
,IGHTLYCOATTHEBURNERSWITHCOOKINGOILTOPREVENTEXCESSRUSTING
)FSTORINGTHEOUTDOORFIREPLACEINDOORSDISCONNECTTHE,0TANKSEEh$ISCONNECT,0'AS4ANKv
SECTIONANDLEAVETHE,0GASTANK/54$//23
0LACETHEPROTECTIVECAPCOVERONTHE,0TANKANDSTORETHETANKOUTDOORSINAWELLVENTILATED
AREAOUTOFDIRECTSUNLIGHT
#OVEROUTDOORFIREPLACEWITHADURABLEVINYLCOVERDESIGNEDTOFITTHISUNIT
3TOREINACOOLANDDRYLOCATIONAWAYFROMCHILDRENANDPETS
Checking for Leaks
WARNING: Before using this outdoor
fireplace, make sure you have read,
understand and are following all
information provided in the Dangers
and Warnings presented on page 2.
Failure to follow those instructions
can cause death, serious injury or
property damage.
Burner Connections
-AKESURETHEREGULATORVALVEANDHOSE
connections are securely fastened to the burner
ANDTHETANK
)FYOURUNITWASASSEMBLEDFORYOUVISUALLYCHECK
THECONNECTIONBETWEENTHEBURNERVENTURIPIPE
ANDORIFICE-AKESURETHEBURNERVENTURIPIPEFITS
OVERTHEORIFICE
WARNING: Failure to inspect
this connection or follow these
instructions could cause a fire or an
explosion which can cause death,
serious bodily injury, or damage to
property.
0LEASEREFERTODIAGRAMFORPROPERINSTALLATION
&IGURESAND
)FTHEBURNERPIPEDOESNOTRESTFLUSHTOTHEORIFICE
PLEASECONTACTFORASSISTANCE
Tank/Gas Line Connection
-AKEOZOFLEAKSOLUTIONBYMIXINGONEPART
LIQUIDDISHWASHINGSOAPWITHTHREEPARTSWATER
-AKESURECONTROLKNOBSAREh/&&
vPOSITION
&IGURE
#ONNECT,0GASTANKPERh)NSTALLING,0'AS4ANKv
SECTION
4URN,0GASTANKVALVETOh/0%.v
3POONSEVERALDROPSOFSOLUTIONORUSESQUIRT
BOTTLEATALLh8vLOCATIONS&IGURESAND
A)FANYBUBBLESAPPEARREMOVETHE,0GASTANK
and reconnect, making sure the connection is
SECURE
B)FYOUCONTINUETOSEEBUBBLESAFTERSEVERAL
ATTEMPTSREMOVETHE,0GASTANKPER
h$ISCONNECT,0'AS4ANKvINSTRUCTIONSAND
CONTACTFORASSISTANCE
C)FNOBUBBLESAPPEARAFTERONEMINUTEWIPE
AWAYSOLUTIONANDPROCEED
Lighting
Caution: Keep outdoor gas cooking
appliance area clear and free from
combustible materials, gasoline and
other flammable vapors and liquids.
Caution: Do not obstruct the flow of
combustion and ventilation air.
Caution: Check and clean burner/
venturi tubes for insects and insect
nests. A clogged tube can lead to a fire beneath the grill.
Caution: Attempting to light the burner with the lid closed may cause
an explosion.
-AKESUREALLLABELSPACKAGINGANDPROTECTIVEFILMSHAVEBEENREMOVEDFROMTHEOUTDOOR
FIREPLACE
-AKESURETHEREARENOOBSTRUCTIONSOFAIRFLOWTOTHEBURNERS3PIDERSANDINSECTSCANNEST
WITHINANDCLOGTHEBURNERVENTURITUBEATTHEORIFICE!CLOGGEDBURNERTUBECANLEADTOA
FIREBENEATHTHEAPPLIANCE
#ONTROLKNOBMUSTBEINTHE
/&&POSITION&IGURE
#ONNECT,0GASTANKPERh#ONNECT,0'AS4ANKvINSTRUCTIONS
4URN,0GASTANKVALVETOh/0%.v
0USHANDTURNCONTROLKNOBTO
,/7
0RESSTHE
ELECTRONICIGNITERBUTTONANDHOLDFORUPTOSECONDSTOLIGHTBURNER
2ELEASECONTROLKNOBAFTERSECONDS
)FIGNITIONDOESNOTOCCURINSECONDSTURNBURNERCONTROLKNOB
/&&WAITMINUTES
ANDREPEATLIGHTINGPROCEDURE
)FIGNITERDOESNOTLIGHTBURNER
A#LEARSMALLAREAOFLAVAROCKSAWAYFROMTHEBURNER
B7EARINGHEATREISTANTGLOVESPOSITIONALITLONGMATCHORLONGLITBUTANELIGHTERNEAR
THESIDEOFTHEBURNER
Operating Instructions
Figure 1
,0'AS6ALVE
WITH/RIlCE
,0'AS
Connection
Figure 2
X
X
X
X
X
Figure 3
OFF
Figure 4
K
F
AA
Figure 5
 previous next