Filter
Top Products
Special offers from our partners!
Find Replacement BBQ Parts for 20,308 Models. Repair your BBQ today.
24 www.ducane.com
HELPFUL HINTS
FLARE UPS
Any time you cook fatty foods over an open flame, you can expect flare ups. Flare ups
are caused by the flash which occurs when the natural juices fall on the heat distribution
plates. Controlled flare ups give foods their delicious outdoor flavor and appearance.
Excessive flare ups may occur when your grill is not level or when cooking fatty foods
such as spare ribs and chicken parts, especially if the cooking temperature is set too
high. These flare ups should be controlled or your food will burn, although it will not burn
nearly as much as you might think even in the direct flame.
m WARNING: Do not spray or pour any liquid into the cooking
box to control flare ups. Doing so will void your warranty
and may damage the grill.
To help control flare ups, we suggest using leaner cuts of meats and trimming excess
fat from the meats to be grilled. Also, your grill should be level. If flare ups do occur,
use the “LO” control setting and relocate the meat on the cooking grid until the flare ups
have subsided.
1) To prevent food from sticking to the grid, preheat the cooking surface with the
hood down for 10 minutes. Place the meat product on the grid and allow it to
remain there for at least half of the suggested grilling time.
2) It is unnecessary to keep flipping meat products— allow them to sear and seal in
their juices, then halfway through the cooking period flip the meat product onto its
other side. When grilling chicken, always place the meat side on the grill first.
3) A light coating of oil applied to any of the meat products prior to grilling will also
help. The use of a commercial spray cooking product is also helpful. This spray
should only be used prior to lighting your grill but never during the cooking period.
Use of spray cooking products can leave a black stain on areas of your cook
grate. This is not harmful and does not affect cooking; however, if this becomes
an appearance problem, the best way to remove the discoloration is by placing
the cooking grate in a self-cleaning oven during the clean cycle.
STORING NATURAL GAS GRILLS
After you have finished cooking and have cleaned your grill, (see Maintenance
section – for cleaning), turn your grill off at your appliance control knob. It is strongly
recommended that the inline field installed cutoff valve also be turned off when the grill
is not in use.
When the portable grill is to be stored indoors, the connection between the hose and the
gas supply line must be broken. While the special fitting will stop the gas flow when the
hose connection is removed, it is highly recommended you turn the gas supply off prior
to disconnecting the hose assembly. To protect the gas fitting, it is necessary to insert
the plastic plug (supplied with 10’ hose package) into the female quick connect. The
male end of the hose must be protected by placing the plastic cap (supplied with 10'
hose package) over the brass fitting on the end of the hose.
GAS VALVE ORIFICE
m WARNING: Any alteration made to the orifice(s) such as
drilling it out, will void your warranty and may result in
serious bodily injury or death, or in a fire or an explosion
causing damage to property.