Filter
Top Products
Special offers from our partners!
Find Replacement BBQ Parts for 20,308 Models. Repair your BBQ today.
2
106497
DIRECT-VENT FIREPLACE
®
SAFETY
INFORMATION
1. Models MBDV37 and MBDV41 use a
millivolt gas control valve and a milli-
volt ignition system. The fireplace in-
cludes a manual variable blower and an
ON/OFF hand-held remote control.
2. This appliance is only for use with the
type of gas indicated on the rating plate.
This appliance is convertible. The stan-
dard factory setup is for natural gas. See
Installation Instructions for Conversion
Natural to Propane/LP, pages 29 and 30.
3. For propane/LP fireplace, do not place
propane/LP supply tank(s) inside any
structure. Locate propane/LP supply
tank(s) outdoors. To prevent perfor-
mance problems, do not use propane/LP
fuel tank of less than 100 lbs. capacity.
4. If you smell gas
• shut off gas supply
• do not try to light any appliance
• do not touch any electrical switch; do
not use any phone in your building
• immediately call your gas supplier
from a neighbor’s phone. Follow the
gas supplier’s instructions
• if you cannot reach you gas supplier,
call the fire department.
5. Never install the fireplace
• in a recreational vehicle
• where curtains, furniture, clothing, or
other flammable objects are less than
42" from the front, top, or sides of
the fireplace
• in high traffic areas
• in windy or drafty areas
6. This fireplace reaches high tempera-
tures. Keep children and adults away
from hot surfaces to avoid burns or cloth-
ing ignition. Fireplace will remain hot
for a time after shutdown. Allow surfaces
to cool before touching.
7. Carefully supervise young children
when they are in the room with fireplace.
8. Do not modify this fireplace under any
circumstances. Any parts removed for
servicing must be replaced prior to op-
erating fireplace.
9. Turn fireplace off and let cool before
servicing, installing, or repairing. Only
a qualified service person should in-
stall, service, or repair this fireplace.
Have fireplace inspected annually by a
qualified service person.
10. You must keep control compartments,
burners, and circulating air passages
clean. More frequent cleaning may be
needed due to excessive lint and dust
from carpeting, bedding material, pet
hair, etc. Turn off the gas valve and pi-
lot light before cleaning fireplace.
11. Have venting system inspected annu-
ally by a qualified service person. If
needed, have venting system cleaned
or repaired. See Cleaning and Mainte-
nance, page 28.
12. Keep the area around your fireplace
clear of combustible materials, gaso-
line, and other flammable vapor and
liquids. Do not run fireplace where
these are used or stored. Do not place
items such as clothing or decorations
on or around fireplace.
13. Do not use this fireplace to cook food
or burn paper or other objects.
14. Do not use any solid fuels (wood, coal,
paper, cardboard, etc.) in this fireplace.
Use only the gas type indicated on fire-
place nameplate.
15. This appliance, when installed, must be
electrically grounded in accordance
with local codes or, in the absence of
local codes, with the National Electri-
cal Code, ANS/NFPA 70, or the Cana-
dian Electrical Code, CSA C22.1.
16. Do not obstruct the flow of combus-
tion and ventilation air in any way. Pro-
vide adequate clearances around air
openings into the combustion chamber
along with adequate accessibility clear-
ance for servicing and proper operation.
17. Do not install fireplace directly on car-
peting, vinyl tile, or any combustible ma-
terial other than wood. The fireplace must
set on a metal or wood panel extending
the full width and depth of the fireplace.
18. Do not use fireplace if any part has been
exposed to or under water. Immediately
call a qualified service person to ar-
range for replacement of the unit.
19. Do not operate fireplace if any log is
broken.
20. Do not use a blower insert, heat ex-
changer insert, or other accessory not
approved for use with this fireplace.
21. Do not operate fireplace with glass door
removed, cracked, or broken.
IMPORTANT: Read this owner’s
manual carefully and completely
before trying to assemble, oper-
ate, or service this fireplace. Im-
proper use of this fireplace can
cause serious injury or death from
burns, fire, explosions, electrical
shock, and carbon monoxide
poisoning.
WARNING: Any change to
this fireplace or its controls can
be dangerous.
WARNINGS
DANGER: Carbon monoxide
poisoning may lead to death!
This fireplace is a vented product. This
fireplace will not produce any gas leakage
into your home if properly installed. This
fireplace must be properly installed by a
qualified service person. The glass door
must be properly seated and sealed. If this
unit is not properly installed by a qualified
service person with glass door properly
seated and sealed, gas leakage can occur.
Carbon Monoxide Poisoning: Early signs
of carbon monoxide poisoning resemble the
flu, with headaches, dizziness, or nausea. If
you have these signs, the fireplace may not
have been installed properly. Get fresh air
at once! Have fireplace inspected and ser-
viced by a qualified service person. Some
people are more affected by carbon monox-
ide than others. These include pregnant
women, people with heart or lung disease or
anemia, those under the influence of alcohol,
and those at high altitudes.
Propane/LP gas and natural gas are both
odorless. An odor-making agent is added to
each of these gases. The odor helps you
detect a gas leak. However, the odor added
to these gases can fade. Gas may be present
even though no odor exists.
Make certain you read and understand all
warnings. Keep this manual for reference. It
is your guide to safe and proper operation of
this fireplace.